E-flite Extra 300 32e ARF User Manual

SpecificationsWingspan: 52.5 inches (1335mm)Wing Area: 542 sq in (34.2 sq dm)Length: 49.0 inches (1245mm)Weight w/Battery: 4.40 – 4.60 lb (1.90–2.

10 E-flite Extra 300 32e ARF Assembly ManualMatching the colors between the ESC and motor when they are connected will result in the correct motor dir

11E-flite Extra 300 32e ARF Assembly Manual 2. The cowling is secured using two (2) 4-40 x 1-inch socket head screws and two (2) #4 washers. You wil

12 E-flite Extra 300 32e ARF Assembly ManualLanding Gear and Wheel InstallationRequired PartsFuselage assembly Axle with hardware (2)#4 washer (5) A

13E-flite Extra 300 32e ARF Assembly Manual 6. Slide the wheel on the axle. Use a 1.5mm hex wrench to tighten the wheel collar that secures the whe

14 E-flite Extra 300 32e ARF Assembly Manual 2. Place the elevator servo in the fuselage with the servo output to the rear. With the servo position

15E-flite Extra 300 32e ARF Assembly ManualStabilizer InstallationRequired PartsFuselage assembly Heavy-duty servo hornElevator and stabilizer assemb

16 E-flite Extra 300 32e ARF Assembly Manual 6. Slide the tubes into the holes at the rear of the fuselage. The stabilizer will fit tight against t

17E-flite Extra 300 32e ARF Assembly Manual 11. Slide the stabilizer tubes in the stabilizer. Use an epoxy brush to apply a thin layer of epoxy on t

18 E-flite Extra 300 32e ARF Assembly ManualElevator InstallationRequired PartsFuselage assembly Control horn assemblyNylon control horn Elevator jo

19E-flite Extra 300 32e ARF Assembly Manual 6. Slide the elevator joiner wire into position in the slot at the rear of the fuselage. 4. Place a T

2 E-flite Extra 300 32e ARF Assembly ManualUsing the ManualThis manual is divided into sections to help make assembly easier to understand, and to pro

20 E-flite Extra 300 32e ARF Assembly Manual 11. Fit the elevator halves to the stabilizer. Remove the T-pins from the hinges. Position the elevator

21E-flite Extra 300 32e ARF Assembly ManualFin InstallationRequired PartsFuselage assembly Fin fairingRudder and fin assemblyRequired Tools and Adhes

22 E-flite Extra 300 32e ARF Assembly ManualRudder and Tail Wheel InstallationRequired PartsFuselage assembly RudderCA hinge (2) Rudder control horn

23E-flite Extra 300 32e ARF Assembly Manual 5. Thread a nylon control horn on each end of the threaded rod. Position the horns so they are flush wit

24 E-flite Extra 300 32e ARF Assembly Manual 10. Mix a small amount of epoxy. Use a toothpick to insert the epoxy in the hole in the rudder where th

25E-flite Extra 300 32e ARF Assembly ManualRudder Pull-Pull Cable InstallationRequired PartsFuselage assembly Rudder cable (2)Cable fitting (4) Cabl

26 E-flite Extra 300 32e ARF Assembly Manual 8. Use low-tack tape to keep the cable from accidentally falling into the fuselage. 9. Slide a clev

27E-flite Extra 300 32e ARF Assembly Manual 15. Slide a crimp on the end of the cable outside the fuselage. The cable then can pass through the hol

28 E-flite Extra 300 32e ARF Assembly ManualWing InstallationRequired PartsFuselage assembly Wing panel (right and left)Carbon wing tube #4 washer (

29E-flite Extra 300 32e ARF Assembly ManualBattery InstallationRequired PartsMotor battery Fuselage assemblyHook and loop strap 1. Use a hook and l

3E-flite Extra 300 32e ARF Assembly ManualRecommended Radio EquipmentYou will need a minimum 6-channel transmitter, receiver and four servos. You can

30 E-flite Extra 300 32e ARF Assembly Manual 6. Lightly sand the inside edge of the canopy at this time as well. Use care not to over-sand the edge

31E-flite Extra 300 32e ARF Assembly ManualElevator High RateUp 21/4-inch (57mm)Down 21/4-inch (57mm)Elevator Low RateUp 3/4-inch (19mm)Down 3/

32 E-flite Extra 300 32e ARF Assembly ManualSafety Do’s and Don’ts for Pilots• Checkallcontrolsurfacespriortoeachtakeoff.• Donotflyyour

33E-flite Extra 300 32e ARF Assembly ManualDAMAGE LIMITSHORIZON SHALL NOT BE LIABLE FOR SPECIAL, INDIRECT OR CONSEQUENTIAL DAMAGES, LOSS OF PROFITS OR

34 E-flite Extra 300 32e ARF Assembly ManualUnited Kingdom:Electronics and engines requiring inspection or repair should be shipped to the following a

35E-flite Extra 300 32e ARF Assembly Manual 8. I will not operate model aircraft carrying pyrotechnic devices which explode burn, or propel a project

16385 Printed 01/2010Horizon Hobby USA4105 Fieldstone RoadChampaign, Illinois 61822USA(877) 504-0233Horizon Hobby UKUnits 1-4 Ployters RdStaple TyeHar

4 E-flite Extra 300 32e ARF Assembly ManualAileron InstallationRequired PartsWing panel with aileron (right and left)CA hinge (10 total)Required Tools

5E-flite Extra 300 32e ARF Assembly Manual 7. Check the alignment of the aileron. Use a ruler to make sure the end of the aileron is aligned evenly

6 E-flite Extra 300 32e ARF Assembly ManualAileron Servo InstallationRequired PartsNylon clevis (2) Clevis retainer (2)Assembled wing panel (right an

7E-flite Extra 300 32e ARF Assembly Manual 5. Secure a 6-inch (152mm) servo extension to the aileron servo lead using string or a commercially avai

8 E-flite Extra 300 32e ARF Assembly ManualWhen installing the servo horn on the aileron servo it must be positioned parallel to the aileron hinge lin

9E-flite Extra 300 32e ARF Assembly ManualMotor InstallationRequired PartsFuselage Motor spacer (4)Speed control Motor with accessories#4 washer (4)